Product ID:AEROSHELL OIL 100 (MIL-L-6082, GR 1100 SAE 50)
MSDS Date:02/22/1995
FSC:9150
NIIN:00-235-9059
MSDS Number: BZPFQ

SHELL OIL COMPANY

HEALTH, SAFETY AND ENVIRONMENT
HOUSTON, TX 77210
US

Emergency Phone: 713-473-9461/800-424-9300(CHEMTREC)

Info Phone: 713-241-4819/4141/2252 FAX -6511

Preparer: J.C. WILLETT

Cage: 54527

SHELL OIL COMPANY

HOUSTON, TX 77210 US

Telephone: 800-231-6950

Cage: 54527

MINERAL OIL, PETROLEUM DISTILLATES,HYDROTREATED

CAS: 64742-54-7

RTECS: PY8035500

Fraction By Weight: 40-50%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

SOLVENT REFINED HYDROTREATED RESIDUAL OIL

CAS: 64742-57-0

Fraction By Weight: 50-60%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

ADDITIVES

Fraction By Weight: <1%

LD50 LC50 Mixture:LD50 (ORAL RAT) > 5 G/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:**TARGET ORGANS:EYE,SKIN,RESPIRATORY
TRACT,CNS** MINIMALLY IRRITATING TO EYES. MILDLY IRRITATING TO
SKIN. INHALATION OF VAPORS OR OIL MIST MAY CAUSE IRRITATION OF
RESPIRATORY TRACT. CONSIDERED NO MORE THAN SLIGHTLY TOXIC.
Explanation of Carcinogenicity:PRODUCT & ITS COMPONENTS ARE NOT
CLASSIFIED AS CARCINOGENS BY IARC, NTP OR OSHA.
Effects of Overexposure:IRRITATION AS NOTED ABOVE.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN &
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:IF IRRITATION PERSISTS OR IS SEVERE, GET MEDICAL ATTENTION.
EYE:FLUSH W/WATER FOR 15 MIN. SKIN:WIPE OFF EXCESS THEN WASH W/SOAP
& WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER BEFORE REUSE.
INHALED:RE MOVE FROM EXPOSURE. AID OR RESTORE BREATHING AS NEEDED.
INGESTED:DO NOT INDUCE VOMITING. IF VOMITING OCCURS PLACE HEAD
BELOWHIPS.

Flash Point Method:COC
Flash Point:470F,243C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CARBON DIOXIDE. DO
NOT USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT & CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED/CONFINED AREA W/O
PROTECTIVE EQUIPMENT & NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS. COOL FIRE EXPOSED CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard:MATERIAL WILL NOT BURN UNLESS PREHEAATED.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. STOP LEAK. DIKE AND
CONTAIN. RECOVER FREE LIQUID. ABSORB REMAINDER. ABSORB SMALL SPILL
ON SAND, CLAY, EARTH & SHOVEL INTO CONTAINERS. PREVENT RUN-OFF TO
ENTER WATERWAYS, SEW ERS.
Neutralizing Agent:MFR GAVE NO INFORMATION OF MSDS.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE W/ADEQUATE
VENTILATION. KEEP AWAY FROM OPEN FLAMES & HIGH TEMPERATURES.
Other Precautions:WASH W/SOAP & WATER BEFORE EATING, DRINKING, SMOKING
OR USING TOILET FACILITIES. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DISCARD CLOTHING THAT CANNOT BE DECONTAMINATED. MINIMIZE
SKIN CONTACT.

Respiratory Protection:IF EXPOSURE DOES OR MAY EXCEED OCCUPATIONAL
EXPOSURE LIMITS, US AN NIOSH APPROVED RESPIRATOR. I/A/W
29CFR1910.134 USE EITHER AN ATMOSPHERE SUPPLYING OR AN AIR
PURIFYING RESPIRATOR FOR ORGANIC VAPOR & PARTICULATES.
Ventilation:MFR GAVE NO INFORMATION OF MSDS.
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:SAFETY GOGGLES
Other Protective Equipment:WEAR PROTECTIVE CLOTHING AS REQUIRED TO
MINIMIZE SKIN CONTACT. NITRILE PROVIDES BEST PROTECTION.
Work Hygienic Practices:WASH W/SOAP & WATER BEFORE
EATING,DRINKING,SMOKING/USING TOILET FACILITIES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IF MORE THAN 2.0 ML PER KG HAS BEEN INGESTED AND
VOMITING HAS NOT OCCURED, EMESIS SHOULD BE INDUCED WITH
SUPERVISION. KEEP VICTIM'S HEAD BELOW HIPS. IF SYMPTOMS SUCH AS
LOSS OF GAG REFLEX, CONVULSION OR UNCONSCIOUSNESS OCCUR, GASTRIC
LAVAGE USING A CUFFED ENDOTRACHEAL TUBE SHOULD BE CONSIDERED.

HCC:V6
NRC/State Lic Num:NONE
Melt/Freeze Pt:M.P/F.P Text:10F,-12C
Vapor Pres:<0.1 MM
Spec Gravity:0.8922
Viscosity:14-16CS @212F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER LIQUID, SLIGHT HYDROCARBON ODOR

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT, OPEN FLAME
Hazardous Decomposition Products:COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES WILL EVOVLE. CARBON MONOXIDE & OTHER
COMPOUNDS MAY FORM.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:NOT A HAZARDOUS WASTE PER RCRA. DISPOSE OF IN
ACCORDANCE WITH LOCAL STATE AND FEDERAL REGULATIONS. CLASSIFIED AS
OIL BY CLEAN WATER ACT. REPORT ANY SPILL ENTERING SURFACE WATERS,
ETC. AS REQUIRED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.